Latest Posts
Steel Surge Tank Coatings
Comments Off on Steel Surge Tank CoatingsThese two new steel surge tanks received a topcoat of Sherwin Williams Acrolon.
Sump Pit Reline with Prefabricated FRP Panels
Comments Off on Sump Pit Reline with Prefabricated FRP PanelsA prefabricated fiberglass liner was installed into a concrete sump pit where the existing FRP liner was unable to be repaired due to chemical permeation.
Tags: fiberglass, frp, liner
U-Drain CPL Repair
Leave a CommentThe plastic liner in this u-drain had collapsed due to improper installation. We completely repaired the liner to properly protect against the corrosive acids that it is in contact with.
Fiberglass Pump Suction Spool Reconstruction
Comments Off on Fiberglass Pump Suction Spool ReconstructionThe plant contacted us with concerns about pinholes. We showed up to do the small repair but were able to completely reconstruct the spool in just 48 hours for a long term solultion.
Tags: emergency repair, fiberglass, repairs
Scrubber Area Acid Lining
Comments Off on Scrubber Area Acid LiningThis metal refining facility was in need of a strong floor coating in their scrubber containment area to protect against hydrofluoric acid.
Clarifier Rake Reline
Comments Off on Clarifier Rake RelineThis clarifier’s rake, shaft and bell housing had a lot of sludge buildup. Universal Blastco was contracted to blast and recoat it.
Rubber Lining in Nuclear Waste Tank
Comments Off on Rubber Lining in Nuclear Waste TankThe largest single rubber lining application to date! This nuclear waste tank spanned 2.5 acres, and holds 32 million gallons.
Tags: rubber lining, tank
Containment Area Repair and Coating
Comments Off on Containment Area Repair and CoatingThis concrete containment area was completely worn down from excessive acid leaks and puddling.
Tags: blasting, coating, containment
New Construction of Tile Filtrate Chest
Comments Off on New Construction of Tile Filtrate ChestUniversal Blastco was contracted by Weiland to build a new 3,500 square foot paper mulch tank for a paper mill in Michigan.
Tags: pulp & paper, tank, tile
Circulating Water Pipe Reline with Structural Fiberglass
Comments Off on Circulating Water Pipe Reline with Structural FiberglassAfter the steel portion of this underground circulating water pipe failed, Universal Blastco built an entire structural fiberglass pipe inside of the existing steel pipe.
Tags: fiberglass, power, steel